Instrukcja obsługi Intellihot i250 Gen II

Intellihot Kotły i bojlery i250 Gen II

Przeczytaj poniżej 📖 instrukcję obsługi w języku polskim dla Intellihot i250 Gen II (64 stron) w kategorii Kotły i bojlery. Ta instrukcja była pomocna dla 2 osób i została oceniona przez 2 użytkowników na średnio 4.5 gwiazdek

Pobierz PDF
Strona 1/64
Operation & Installation Manual
i200, Gen II
i250, Gen II
WARNING
If the information in these instructions is not followed
exactly, a re or explosion could result causing
property damage, personal injury, or death.
— Do not store or use gasoline r other ammable o
vapors and liquids in the vicinity of this or any
other appliance.
WHAT TO DO IF YOU SMELL GAS
• Do not try to light any appliance.
• Do not touch any electrical switch; do not use
any phone in your building.
• Immediately call our gas uppliery s from a
neighbor’s phone. Follow the gas supplier’s
instructions.
• If you cannot reach your gas supplier, call the
re department.
— Installation and service must e performed by b
a qualied installer, service agency, or the gas
supplier.
— Ne pas entreposer ni utiliser d’essence ou
ni d’autres vapeurs ou liquides inammables
à proximité de cet appareil ou de tout autre
appareil.
QUE FAIRE SI VOUS SENTEZ GAUNE ODEUR DE Z
•
Ne pas tenter d’allumer d’appareil.
•
Ne touchez à aucun interrupteur; ne pas vous
s t tervir des éléphones se rouvant dans
le bâtiment.
•
Appelez immédiatement votre fournisseur de gaz
depuis un voisin. uivez les instructionS s
du fournisseur.
•
Si vous ne pouvez rejoindre le fournisseur,
appelez le service des incendies.
— L’installation et l’entretien doivent être assurés
par un installateur ou un service d’entretien
qualié ou par le fournisseur de gaz.
AVERTISSEMENT
Assurez-vous de bien suivre les instructions données
dans cette notice pour réduire au minimum le
risque d’incendie ou d’explosion ou pour éviter tout
dommage matériel, toute blessure u la mort. o
Thank you for purchasing this Intellihot unit.
This unit is designed for years of trouble free operation, and I urge you to read and follow the
instructions in this “Operation & Installation Manual.”
Our mission to create a better heating system began back in the winter of 2005 when a tank
water heater broke down and ooded my basement. By combining the principles of a diesel
engine’s robustness, robotics intelligence, and marine environment durability, we set out to
design a unit from the ground up that would outperform and outlast all others.
Quickly, our goal grew from not just making a better water heater, but creating an intelligent
water heating and delivery system. Innovation is our hallmark and simplicity, eciency, and
durability are at the core of every lntellihot product.
Our products are proudly engineered and built in Galesburg, Illinois. lntellihot has helped
commercial customers throughout the nation save thousands of dollars while eliminating
downtime. Our talented team of dedicated professionals is ready to assist you and help your
business succeed.
I thank you for purchasing our lntellihot products.
Sincerely,
Sri Deivasigamani
CEO, lntellihot Inc.
3 i200 / i250
Jan 2021 - Revision 01
Table of Contents
1. General Information
1.1 Items Shipped With Water Heater 5. . . . . . . . . .
1.2 Serial Number Plate Locations 5 . . . . . . . . . . . .
2. Safety
2.1 Safety Signal Words 6. . . . . . . . . . . . . . . . . . . . .
2.2 Installation Warnings 6 . . . . . . . . . . . . . . . . . . . .
3. TechnicalSpecications
3.1 SpecicationsChart ....................8
3.2 High Elevation Installations 9 . . . . . . . . . . . . . . .
3.3 ClearanceRequirements .................9
3.4 Connections ...........................9
3.5 Exhaust Gas Standards 9 . . . . . . . . . . . . . . . . . .
3.6 DimensionalSpecications .............. 10
4. Preparation Before Installation
4.1 Selecting an Indoor Installation Site . . . . . . . . 11
4.2 Selecting an Outdoor Installation Site 12. . . . . .
5. Wall Mounting
5.1 Mounting the Unit to the Wall 13 . . . . . . . . . . . .
6. Gas Connection
6.1 Quick Reference Installation Instructions 14 . . .
6.2 Fuel Source 14 ..........................
6.3 GasPressureRequirements ............. 14
6.4 Gas Pressure Regulator 14. . . . . . . . . . . . . . . . .
6.4.1 Venting of Gas Supply Regulators 14 . . .
6.5 Length of Gas Supply Pipe 14 . . . . . . . . . . . . . .
6.6 Gas Piping Material 15 . . . . . . . . . . . . . . . . . . . .
6.7 DetermineCorrectGasPipeDiameter . . . . . 15
6.8 GasPipeDripLegandShut-oValve ...... 15
6.9 Gas Pipe Sizing Tables 16. . . . . . . . . . . . . . . . . .
7. Air Intake Inlet and Exhaust Gas Outlet Pipe
Connections
7.1 Quick Reference Installation Guide 18. . . . . . . .
7.2 Typical Single Unit Air Intake Inlet and
Exhaust Gas Outlet Pipe Installation 18. . . . . . .
7.3 Two Pipe Vent System (Direct Vent) 19 . . . . . .
7.3.1 SingleUnitCongurations ......... 19
7.3.2 MultipleUnitsCongurations . . . . . . . 20
7.3.3 Side Wall Air Intake Inlet and Exhaust
Gas Outlet Pipe Termination 20. . . . . . . .
7.3.4 Roof Air Intake Inlet and Exhaust
Gas Outlet Pipe Termination 21. . . . . . . .
7.4 Single Pipe Venting System (Power Vent) 21 . .
7.4.1 Single Unit 21......................
7.4.2 Multiple Units 22 . . . . . . . . . . . . . . . . . . .
7.4.3 ConcentricVentingTermination
(Single Unit) 22 . . . . . . . . . . . . . . . . . . . .
7.4.4 ConcentricVentingTermination
(Multiple Units) 23. . . . . . . . . . . . . . . . . .
7.5 IntakeAirRequirements ................24
7.6 Intake Air Inlet and Exhaust Gas Outlet
Pipe Diameter and Length 25. . . . . . . . . . . . . . .
7.7 VentingClearanceSpecications .........26
7.8 Exhaust Gas Outlet Pipe Materials . . . . . . . . 27
7.9 Air Intake Inlet Pipe Vent Materials . . . . . . . . 27
7.10 Recommended Exhaust Gas Outlet Pipe
Transitions ...........................28
8. Water Connections
8.1 Quick Reference Installation Instructions 29 . . .
8.2 HotWaterConnection ..................29
8.3 ColdWaterConnection .................30
8.4 CondensateDrainLine ..................30
8.5 External Recirculation Options 32 . . . . . . . . . . .
9. Electrical
9.1 ElectricalCodeRequirements ............34
9.2 ElectricalConnectionandPolarity.........34
10. Adjusting CO2 Level
10.1 General Information 35. . . . . . . . . . . . . . . . . . . .
10.2 Adjustment Procedure 35. . . . . . . . . . . . . . . . . .
11. Natural Gas to Propane Conversion
11.1 General Information 38. . . . . . . . . . . . . . . . . . . .
11.2 ConversionProcedure .................38
12. Operation
12.1 ControlPanel .........................40
12.2 Turning Water Heater ON and OFF 40. . . . . . . .
12.3 Setting the Time 41 . . . . . . . . . . . . . . . . . . . . . .
12.4 Adjusting the Water Temperature 41. . . . . . . . .
12.5 Security .............................42
12.5.1 Setting Passcode Protection 42 . . . . . . .
12.5.2 Forgot Passcode 42 . . . . . . . . . . . . . . . . .
12.6 Life Screen 43...........................
12.7 Unit Information 43. . . . . . . . . . . . . . . . . . . . . . .
12.8 More Screens 44.........................
12.8.1 Error History 44 . . . . . . . . . . . . . . . . . . . .
13. Connecting Multiple Units
13.1 General Information 45 ...................
13.2 Installation Procedure 45. . . . . . . . . . . . . . . . . .
14. Maintenance
14.1 CleaningtheInletWaterStrainer .........47
14.2 Draining the Water Heater . . . . . . . . . . . . . . . 47
14.3 Filling the Water Heater 48. . . . . . . . . . . . . . . . .
15. Wiring Diagrams and Troubleshooting
15.1 OperationalFlowChart .................49
15.2 CompleteWiringDiagram(allmodels) . . . . . 50
15.3 Troubleshooting Guide . . . . . . . . . . . . . . . . . . 51
16. Serviceable Parts
17. Requirements for State of Massachusetts
17.1 Notice Before Installation 5. . . . . . . . . . . . . . . 9
18. Warranty
18.1 Warranty.............................60
19. Product Warranty Card
19.1 WarrantyCard ........................62
16.1 Electrical Components . . . . . . . . . . . . . . . . . 56
16.2 Water Lines and Fittings . . . . . . . . . . . . . . . . 57
16.3 Blower, Gas Valve . . . . . . . . 58and . . . .. . . .. . . .
16.4 Exhaust and Air Intake . . . . . . . . . . . . . . . . . . 59
16.5 Miscellaneous . . . .. . . . . . . . . . . . . . . . . . . . . . 60

Specyfikacje produktu

Marka: Intellihot
Kategoria: Kotły i bojlery
Model: i250 Gen II

Potrzebujesz pomocy?

Jeśli potrzebujesz pomocy z Intellihot i250 Gen II, zadaj pytanie poniżej, a inni użytkownicy Ci odpowiedzą


Instrukcje Kotły i bojlery Intellihot

Intellihot

Intellihot iQ2001 Gen II Instrukcja

17 Września 2024
Intellihot

Intellihot iQ251D Gen II Instrukcja

17 Września 2024
Intellihot

Intellihot iQ1501 Gen II Instrukcja

16 Września 2024
Intellihot

Intellihot i250 Gen II Instrukcja

16 Września 2024
Intellihot

Intellihot iQ251 Gen II Instrukcja

16 Września 2024
Intellihot

Intellihot i200 Gen II Instrukcja

15 Września 2024
Intellihot

Intellihot iN199 Instrukcja

15 Września 2024
Intellihot

Intellihot iQ3001 Gen II Instrukcja

15 Września 2024
Intellihot

Intellihot iN401 Instrukcja

15 Września 2024
Intellihot

Intellihot iQ1001 Gen II Instrukcja

15 Września 2024

Instrukcje Kotły i bojlery

Najnowsze instrukcje dla Kotły i bojlery

Sencor

Sencor SWK 7706GD Instrukcja

14 Października 2024
Hotpoint

Hotpoint HE30S01SAG Instrukcja

13 Października 2024
Nibe

Nibe VPA 300/200 E Instrukcja

9 Października 2024
Noritz

Noritz NC199OD Instrukcja

9 Października 2024
Nibe

Nibe Melite 120 Instrukcja

8 Października 2024
Nibe

Nibe VPB 500-1000 Instrukcja

8 Października 2024
MicroHeat

MicroHeat CFEWH SERIES 2 Instrukcja

8 Października 2024
Elba

Elba EWH-E3881(SW) Instrukcja

8 Października 2024
Elba

Elba EWH-E3885DC(SG) Instrukcja

8 Października 2024
Elba

Elba EWH-G3661(MB) Instrukcja

8 Października 2024