Instrukcja obsługi Canarm ALX135-DD050V
Canarm
Wentylator
ALX135-DD050V
Przeczytaj poniżej 📖 instrukcję obsługi w języku polskim dla Canarm ALX135-DD050V (6 stron) w kategorii Wentylator. Ta instrukcja była pomocna dla 4 osób i została oceniona przez 2 użytkowników na średnio 4.5 gwiazdek
Strona 1/6
ALX SERIES
SPUN ALUMINUM EXHAUSTER
OPERATION INSTRUCTIONS AND PARTS MANUAL
READ AND SAVE THESE INSTRUCTIONS
GENERAL SAFETY
1. All electrical work must be done in accordance with all applicable electrical codes by a
qualified electrician.
2. Prior to wiring ensure the power supply is locked in the OFF position and that the motor
nameplate voltage matches the supply voltage.
3. Do not install or operate this fan in an environment where combustible materials, gases or
fumes are present.
4. Caution: the fan contains rotating parts and electrical service. Appropriate safety
precautions should be taken during installation, operation and maintenance.
When servicing the fan motor may be hot, allow time for cooling down.
5. Before starting the unit, ensure the wheel rotates freely.
6. Check and tighten where necessary all nuts, bolts & set screws prior to fan start up (as
some may have loosened during shipment).
7. Please follow all applicable national, state/provincial and local codes, all of them will
supersede this manual.
8. Failure to follow the safety instructions in this manual may cause serious injury or
death due to electrical shock or high speed rotating parts.
The purpose of this manual is to aid in the proper installation and operation of the blowers. These instructions are intended to supplement good
general practices and are not intended to cover detailed instruction procedures.
IT IS THE RESPONSIBILITY OF THE PURCHASER TO ASSURE THAT THE INSTALLATION AND MAINTENANCE OF THIS EQUIPMENT IS
HANDLED BY QUALIFIED PERSONNEL.
Inspect all shipments carefully for damage. THE RECEIVER MUST NOTE ANY DAMAGE ON THE CARRIER’S BILL OF LADING AND FILE A
CLAIM IMMEDIATELY WITH THE FREIGHT COMPANY.
DO NOT LIFT THE UNIT BY THE HOOD OR MOTOR. PLEASE LIFT THE UNIT BY HORIZONTAL SUPPORTS.
DIMENSION & COMPONENT
ALX-M-10_04_16 Page 1 of 6
A
B
D
E
C
G
F
A
B
D
E
C
G
F
UPBLAST
MODELS
DOWNBLAST
MODELS
NOTE: DUE TO MOTOR MANUFACTURERS VARIANCES IN DESIGN,
PLEASE SEE PAGE 5 FOR MOTOR DIMENSIONAL GUIDELINES.
DOWNBLAST UPBLAST
Downblast Direct
Drive Shown
Note: Belt drive units are weighted without motor & drives.
Upblast Belt
Drive Shown
Motor plate detail varies
on different sizes
Model A B C D E F G Ø Wheel
Diameter
Roof
Opening
Net
Weight
(lbs)
ALX105-DD 18.00 25.00 19.00 2.50 1.50 3.50 0.38 10.50 15.00 33
ALX120-DD 19.00 25.00 19.00 3.50 1.50 3.50 0.38 12.25 15.00 35
ALX135-DD/DB 22.25 / 25.25 31.25 21.00 3.13 2.00 3.75 0.44 13.50 17.00 51 / 59
ALX150-DD/DB 23.13 / 26.13 31.25 21.00 3.75 2.00 3.75 0.44 15.00 17.00 56 / 65
ALX165-DD/DB 27.13 / 31.13 36.25 24.75 5.00 2.00 4.00 0.44 16.50 20.75 100 / 106
ALX180-DD/DB 27.75 / 31.75 36.25 24.75 5.50 2.00 4.00 0.44 18.25 20.75 104 / 110
ALX210-DB 36.25 43.75 33.13 5.25 2.50 4.00 0.44 21.25 29.00 176
ALX245-DB 37.00 43.75 33.13 5.88 2.50 4.00 0.44 24.50 29.00 181
Dimensions (inches)
Model A B C D E F G Ø Wheel
Diameter
Roof
Opening
Net
Weight
(lbs)
ALX105-UD 17.63 25.00 19.00 13.00 1.50 3.50 0.38 10.50 15.00 35
ALX120-UD 18.63 25.00 19.00 13.00 1.50 3.50 0.38 12.25 15.00 37
ALX135-UD/UB 22.25 / 25.25 32.13 21.00 17.13 1.50 3.75 0.44 13.50 17.00 53 / 62
ALX150-UD/UB 23.13 / 26.13 32.13 21.00 17.13 1.50 3.75 0.44 15.00 17.00 58 / 67
ALX165-UD/UB 27.13 / 31.13 37.50 24.75 21.13 2.00 4.00 0.44 16.50 20.75 100 /108
ALX180-UD/UB 27.75 / 31.75 37.50 24.75 21.13 2.00 4.00 0.44 18.25 20.75 108 / 116
ALX210-UB 36.25 43.75 33.13 25.50 2.50 4.00 0.44 21.25 29.00 178
ALX245-UB 37.00 43.75 33.13 25.50 2.50 4.00 0.44 24.50 29.00 183
Dimensions (inches)
!
ALX SERIES
SPUN ALUMINUM EXHAUSTERS
ALX-M-10_04_16 Page 2 of 6
1. A qualified electrician in accordance with all local and National Electrical Codes should do all wiring.
2. Ensure power supply is disconnected and locked out prior to making electrical connections.
3. Wire the motor according to the wiring diagram on motor label or on the sticker inside the motor wrap. All motors should be wired to
the same rotation as indicated on the sticker on the top plate.
4. Leave enough slack in the wiring to allow for motor movement when adjusting the belt tension.
5. Excess wire must be restrained in order to prevent it from entering the pulley, shaft or wheel rotating area.
6. Disconnect switches are recommended and should be located near the fan in order to, swiftly cut off power in case of an emergency
and maintain complete control of the power source.
Some single phase direct drive motor’s running RPM can be adjustable with a variable speed control (please contact factory for more
information). The speed control knob starts at off position, then high to low adjust range. At high speed, the speed control would allow the
motor running at its maximum RPM. Dial the knob to the low side would let the speed control regulate the voltage on the motor to reduce
the RPM.
A minimum speed adjustment is needed to limit the motor RPM range. Follow this procedure to set the minimum speed.
1. Motor must be in servicing status to allow the minimum speed setting. Motor would not slow down unless proper load is applied.
Motor RPM would be changed under different system (static pressure).
2. Turn the main control knob to the lowest speed position.
3. Locate and adjust the minimum speed setting, it can be found on the control box itself.
4. Motor RPM range would be from full RPM to the RPM just set.
The lowest minimum voltage that may be applied to the motors is 65VAC. Running at lower voltage can cause premature failure
to the motor.
For 3 phase motors, a variable frequency drive (VFD) is required to adjust motor speed.
VARIABLE SPEED CONTROL – SINGLE PHASE
VARIABLE FREQUENCY DRIVE – THREE PHASE
INSTALLATION
R D DECOMMEN E
ROOF OPENING
WI E T P WER D O O R
B O RY THE S
ROOF
D CE K
O O D C CPTI NAL ISCONNE T AN
B D DE MOUNTE INSI E THE
H EOUSING OR OUTSID
MINIM M U 12”
R D DECOMMEN E
ROOF OPENING
ROOF
D CE K
MINIM M U 12”
WI E PTI N R O O 2:
WIRE THROUGH
THE VENT TUBE
WI E PTI N R O O 1:
TH N ITROUG COH DU
GENERAL CLEAN AIR APPLICATION (UP BLAST) GENERAL CLEAN AIR APPLICATION, DOWN BLAST
Note: ALX105 and ALX120 has only wiring option 1, ALX210 and larger has
only wiring option 2 available.
STANDARD WIRING INSTRUCTIONS
1. Install roof curb, caulk and flash to ensure the water tightness.
2. Rotate the blower wheel by hand. Wheel should not be rubbing against the housing inlet. If rubbing occurs, loosen the set screws on
the wheel hub and shift the wheel to obtain clearance. Then re-tighten all set screws.
3. Complete all subsequent duct connections.
4. Secure the fan to the curb cap. Do not lift the unit by the hood or motor. Lift the unit by horizontal supports on direct drive or by motor
mounting plate for belt drive unit.
5. Use at least 8 proper fasteners to connect the blower base to the roof curb.
6. Verify if the power supply is compatible with the equipment.
7. Make sure the power line is shut down before wiring the motor to power line.
8. Remove top cap, connect power line to the motor/disconnect switch as indicated.
9. For all up blast units, the electrical supply enters the motor compartment through the vent tube.
10. Ensure all fasteners and set screws are tightened.
11. Place the top cap back on the hood.
12. Caulk and flash the fan base including the fan base corners and roof curb to ensure good water tightness.
MESSAGE DISPLAYED...
Spd- followed by the instantaneous speed in rpm
dE- followed by S + demand in %
E1- No communications
E2- Under Voltage
All up-blast models are UL/cUL listed, they are capable to meet UL762 for Commercial Kitchen application:
• The National Fire Protection Association (NFPA) publication NFPA 96 is the primary source for this application. Also consult local
authorities for all other applicable codes and guidelines before installation.
• Exhaust fans used in kitchen ventilation applications must have external wiring. (Wiring must not be installed in the airstream).
• Installation must include a means for inspecting, cleaning and servicing the exhaust fan. (Curb hinge, grease collector and outdoor
disconnect switches are available for purchase as accessories)
• No dampers can be used in the system.
UL762 RESTAURANT EXHAUST APPLICATION
Power is connected to the motor and control module through
the junction box and wiring harness provided.
Note: For 115VAC operation the blue jumper provided (taped
to wire harness) must be inserted into motor power
connector. See diagram.
Caution: Operating the motor at 208-230VAC with the jumper will cause significant damage to the motor.
AC Supply - 115/208-230VAC
EC motors are equipped with a control module that allows for accurate
manual adjustment of motor speed. Motor speed range is from 300 to
1800rpm or maximum rpm for that model.
The control module features a 4 digit LED display that indicates %
demand of full speed and motor speed in rpm. The display also indicates
an error code message for minor diagnostics if required.
Motor speed can be changed by adjusting the speed control pot located
on the control module. A small screwdriver can be used to make the
speed adjustment.
ALX SERIES
SPUN ALUMINUM EXHAUSTERS
ALX-M-10_04_16 Page 3 of 6
EC (Electronically Controlled) MOTOR SPEED CONTROL
Note: EC motors have a soft start feature. When the power is turned on the control module gathers information from the motor then begins
the start up process. After a few seconds the motor will start to turn and reach full set speed in 10-15 seconds.
Remote Speed Control Option (please contact factory for further information)
Specyfikacje produktu
| Marka: | Canarm |
| Kategoria: | Wentylator |
| Model: | ALX135-DD050V |
Potrzebujesz pomocy?
Jeśli potrzebujesz pomocy z Canarm ALX135-DD050V, zadaj pytanie poniżej, a inni użytkownicy Ci odpowiedzą
Instrukcje Wentylator Canarm
2 Stycznia 2025
1 Stycznia 2025
1 Stycznia 2025
1 Stycznia 2025
22 Września 2024
22 Września 2024
22 Września 2024
22 Września 2024
22 Września 2024
22 Września 2024
Instrukcje Wentylator
- Wentylator Tesy
- Wentylator DeLonghi
- Wentylator AEG
- Wentylator Beko
- Wentylator Worx
- Wentylator Küppersbusch
- Wentylator Beurer
- Wentylator Gorenje
- Wentylator Tefal
- Wentylator Milwaukee
- Wentylator Philips
- Wentylator Livoo
- Wentylator SilverCrest
- Wentylator Bosch
- Wentylator SHE
- Wentylator JBL
- Wentylator LC-Power
- Wentylator Brentwood
- Wentylator Midea
- Wentylator Toolcraft
- Wentylator Severin
- Wentylator Infiniton
- Wentylator Panasonic
- Wentylator StarTech.com
- Wentylator Nedis
- Wentylator Stanley
- Wentylator Be Cool
- Wentylator Medion
- Wentylator Black & Decker
- Wentylator OK
- Wentylator Adler
- Wentylator Westinghouse
- Wentylator Quigg
- Wentylator Domo
- Wentylator Ardes
- Wentylator Taurus
- Wentylator Orbegozo
- Wentylator Blaupunkt
- Wentylator Vivax
- Wentylator Siemens
- Wentylator Evolveo
- Wentylator Stadler Form
- Wentylator DeWalt
- Wentylator Homedics
- Wentylator Jocel
- Wentylator Bimar
- Wentylator Rowenta
- Wentylator Mesko
- Wentylator Master
- Wentylator Honeywell
- Wentylator Concept
- Wentylator Fisher & Paykel
- Wentylator Tripp Lite
- Wentylator ECG
- Wentylator Akasa
- Wentylator Unold
- Wentylator Antari
- Wentylator Ozito
- Wentylator ORNO
- Wentylator Dyson
- Wentylator Broan
- Wentylator Trisa
- Wentylator RYOBI
- Wentylator Alpine
- Wentylator Gembird
- Wentylator Zelmer
- Wentylator Trust
- Wentylator Bomann
- Wentylator Clean Air Optima
- Wentylator Teesa
- Wentylator Corsair
- Wentylator Emerio
- Wentylator Create
- Wentylator Biltema
- Wentylator Crane
- Wentylator H.Koenig
- Wentylator Melissa
- Wentylator V-TAC
- Wentylator Beper
- Wentylator Eurolite
- Wentylator MPM
- Wentylator OneConcept
- Wentylator Emos
- Wentylator Ravanson
- Wentylator Crivit
- Wentylator BaseTech
- Wentylator Thermex
- Wentylator Perel
- Wentylator Fagor
- Wentylator GoldAir
- Wentylator Koenic
- Wentylator Trotec
- Wentylator Trumatic
- Wentylator Izzy
- Wentylator Klarstein
- Wentylator Cecotec
- Wentylator AFK
- Wentylator Camry
- Wentylator Steba
- Wentylator NewAir
- Wentylator Qlima
- Wentylator Helios
- Wentylator Scarlett
- Wentylator Sôlt
- Wentylator GUTFELS
- Wentylator Nevir
- Wentylator TriStar
- Wentylator Dimplex
- Wentylator Baxi
- Wentylator SPC
- Wentylator DCG
- Wentylator Brandson
- Wentylator Vornado
- Wentylator G3 Ferrari
- Wentylator Omega Altise
- Wentylator Clatronic
- Wentylator Inventum
- Wentylator SVAN
- Wentylator Ariete
- Wentylator Princess
- Wentylator Innoliving
- Wentylator Argoclima
- Wentylator Sunbeam
- Wentylator Solac
- Wentylator Hama
- Wentylator Heller
- Wentylator Duronic
- Wentylator Comfee
- Wentylator Goobay
- Wentylator Meaco
- Wentylator Sharkoon
- Wentylator Kenmore
- Wentylator Breville
- Wentylator VOX
- Wentylator Esperanza
- Wentylator Orima
- Wentylator Solis
- Wentylator Aspes
- Wentylator Orion
- Wentylator Nitecore
- Wentylator SereneLife
- Wentylator Craftsman
- Wentylator Frigidaire
- Wentylator Wahoo Fitness
- Wentylator Gemini
- Wentylator Thermaltake
- Wentylator Hunter
- Wentylator Martin
- Wentylator PowerPlus
- Wentylator Gaggenau
- Wentylator Sencor
- Wentylator Vonroc
- Wentylator HiKOKI
- Wentylator Nabo
- Wentylator EasyMaxx
- Wentylator Fuave
- Wentylator Asko
- Wentylator Kalorik
- Wentylator Suntec
- Wentylator Be Quiet!
- Wentylator Carrier
- Wentylator Monacor
- Wentylator Livington
- Wentylator Kunft
- Wentylator Grunkel
- Wentylator Becken
- Wentylator Smartwares
- Wentylator Magmatic
- Wentylator ProfiCare
- Wentylator Guzzanti
- Wentylator InnoGIO
- Wentylator Cotech
- Wentylator Eurom
- Wentylator Enermax
- Wentylator Clas Ohlson
- Wentylator Arctic Cooling
- Wentylator PRIME3
- Wentylator Sonnenkönig
- Wentylator Proline
- Wentylator Lasko
- Wentylator Soler & Palau
- Wentylator Bestron
- Wentylator Profile
- Wentylator Swan
- Wentylator Alpina
- Wentylator Andrews
- Wentylator Argo
- Wentylator KDK
- Wentylator Qazqa
- Wentylator EXCELLENT Electrics
- Wentylator Techwood
- Wentylator Korona
- Wentylator Tomado
- Wentylator Eglo
- Wentylator Kichler
- Wentylator Sinbo
- Wentylator Jata
- Wentylator Itho
- Wentylator Sun Joe
- Wentylator Mellerware
- Wentylator Heinner
- Wentylator Termozeta
- Wentylator Eldom
- Wentylator Defy
- Wentylator Bionaire
- Wentylator Premium
- Wentylator White Knight
- Wentylator BlueBuilt
- Wentylator Trebs
- Wentylator Evolar
- Wentylator Air King
- Wentylator Costway
- Wentylator Elba
- Wentylator Royal Sovereign
- Wentylator EcoAir
- Wentylator Everglades
- Wentylator Heylo
- Wentylator Listo
- Wentylator Ufesa
- Wentylator CasaFan
- Wentylator Duux
- Wentylator Gamma
- Wentylator Primo
- Wentylator German Pool
- Wentylator Hema
- Wentylator Ices
- Wentylator Zehnder
- Wentylator Bulex
- Wentylator Essentiel B
- Wentylator Team
- Wentylator Fantini Cosmi
- Wentylator Boneco
- Wentylator Efbe-schott
- Wentylator Tornado
- Wentylator Superior
- Wentylator Day
- Wentylator HQ
- Wentylator Fakir
- Wentylator Arno
- Wentylator Proklima
- Wentylator PAX
- Wentylator Waves
- Wentylator Orcon
- Wentylator Home Electric
- Wentylator Tron
- Wentylator Duracraft
- Wentylator Khind
- Wentylator Tecnolux
- Wentylator Guardo
- Wentylator Weasy
- Wentylator Klarbach
- Wentylator CSL
- Wentylator Handson
- Wentylator Orava
- Wentylator Schweigen
- Wentylator Ausclimate
- Wentylator Hornbach
- Wentylator Jan Des Bouvrie
- Wentylator Sportstech
- Wentylator Sichler
- Wentylator SMC
- Wentylator Baseline
- Wentylator Kogan
- Wentylator Arebos
- Wentylator Portacool
- Wentylator Martec
- Wentylator Air & Me
- Wentylator Wahlbach
- Wentylator Neo
- Wentylator SPT
- Wentylator Rovus
- Wentylator Rok
- Wentylator Madeira
- Wentylator Siku
- Wentylator PureGuardian
- Wentylator Aerian
- Wentylator Claro
- Wentylator IXL
- Wentylator XPower
- Wentylator JAP
- Wentylator O2 Cool
- Wentylator Elix
- Wentylator Prem-i-air
- Wentylator Arcoaire
- Wentylator Bodin
- Wentylator Djive
- Wentylator Casablanca
- Wentylator B-Air
- Wentylator Wallair
- Wentylator White Shark
- Wentylator Maico
- Wentylator Envira-North
- Wentylator Vitammy
- Wentylator SEPA
- Wentylator Frankische
- Wentylator SchwankAir
- Wentylator Calibo
- Wentylator Blumill
- Wentylator Fantech
- Wentylator Stylies
- Wentylator RestantOutlet
- Wentylator Aeratron
- Wentylator ActiveJet
- Wentylator Protector
- Wentylator Migros
- Wentylator Briebe
- Wentylator Fanco
- Wentylator Big Ass Fans
- Wentylator Salco
- Wentylator SpeedComfort
- Wentylator Vortice
- Wentylator Klimat
- Wentylator Eligent
- Wentylator Gewiss
- Wentylator Cli-Mate
- Wentylator Phaesun
- Wentylator Middle Atlantic
- Wentylator Kincrome
- Wentylator AireRyder
- Wentylator Lucci
- Wentylator Fanimation
- Wentylator Air Logic
- Wentylator Ebm-papst
- Wentylator Sandia Aerospace
- Wentylator HPM
- Wentylator Geek Aire
- Wentylator Imarflex
- Wentylator Perfect Aire
- Wentylator Mystery
- Wentylator S&P
- Wentylator Modern Fan Co.
- Wentylator Quorum International
- Wentylator Yamazen
- Wentylator Windmill
Najnowsze instrukcje dla Wentylator
5 Stycznia 2025
5 Stycznia 2025
5 Stycznia 2025
5 Stycznia 2025
3 Stycznia 2025
3 Stycznia 2025
2 Stycznia 2025
2 Stycznia 2025
2 Stycznia 2025
2 Stycznia 2025