Instrukcja obsługi Hatco 3CS-6-208-3-QS

Hatco Podgrzewacz 3CS-6-208-3-QS

Przeczytaj poniżej 📖 instrukcję obsługi w języku polskim dla Hatco 3CS-6-208-3-QS (20 stron) w kategorii Podgrzewacz. Ta instrukcja była pomocna dla 2 osób i została oceniona przez 2 użytkowników na średnio 4.5 gwiazdek

Pobierz PDF
Strona 1/20
© 2012 Hatco Corporation
Sanitizing Sink Heaters and
Food Rethermalizers/Bain-Marie Heaters
3CS and FR Series
Installation and Operating Manual
P/N 07.04.114.00
POWER
ON
LOW WATER
REFILL & RESET
PARTS & SERVICE
ASSIST ANCE
www.hatcocorp.com
800-558-0607
Fill sink before turni ng p ower o n.
Disco nnect p ower b efore se rvicin g heater .
RESET
ON
OFF
WATER HEATER
HAT CO C ORP. MILWAU KEE, WI U .S.A
U.S. PAT. NO. 3291965 CAN. PAT. NO. 761083
POWER
ON
WATER AT
TEMPERA TURE
PARTS & SER
VICE
ASSIS TANCE
www.h atcocorp.com
800-558-0607
Fill sink before turnin g power on.
Drain and clean hea te
r daily.
RESET
ON
OFF
WATER HEATER
HATCO CORP. MILWAUKEE, WI U .S.A
U.S. PAT
. NOS. 3291965 3636308
Do not operate this equipment unless you
have read and understood the contents of
this manual! Failure to follow the
instructions contained in this manual may
result in serious injury or death. This
manual contains important safety
information concerning the maintenance,
use, and operation of this product. If
you’re unable to understand the contents
of this manual, please bring it to the
attention of your supervisor. Keep this
manual in a safe location for future
reference.
No opere este equipo al menos que haya
leído y comprendido el contenido de este
manual! Cualquier falla en el seguimiento
de las instrucciones contenidas en este
manual puede resultar en un serio lesión
o muerte. Este manual contiene
importante información sobre seguridad
concerniente al mantenimiento, uso y
operación de este producto. Si usted no
puede entender el contenido de este
manual por favor pregunte a su
supervisor. Almacenar este manual en
una localización segura para la referencia
futura.
Ne pas utiliser cet équipement sans avoir
lu et compris le contenu de ce manuel !
Le non-respect des instructions
contenues dans ce manuel peut entraîner
de graves blessures ou la mort. Ce
manuel contient des informations
importantes concernant l'entretien,
l'utilisation et le fonctionnement de ce
produit. Si vous ne comprenez pas le
contenu de ce manuel, veuillez le signaler
à votre supérieur. Conservez ce manuel
dans un endroit sûr pour pouvoir vous y
référer plus tard.
WARNING
ADVERTENCIA
AVERTISSEMENT
Register Online!
(see page 2)
www.hatcocorp.com
Important Owner Information ..............................................2
Introduction...........................................................................2
Important Safety Information...............................................3
NSF Criteria.....................................................................4
Model Description.................................................................5
All Models ........................................................................5
3CS Models .....................................................................5
FR Models.......................................................................5
FRC Models ....................................................................5
Model Designations..............................................................5
Specifications........................................................................6
Plug Configurations .........................................................6
Electrical Rating Chart—3CS Models..............................6
Electrical Rating Chart—FR Models................................8
Electrical Rating Chart—FRC Models .............................9
Dimensions....................................................................10
Installation ............................................
General ..........................................................................11
Sizing Information ..........................................................11
Installing 3CS and FR Models .......................................11
Installing FRC Models....................................................13
Electrical Information .....................................................13
Operation.............................................
General..........................................................................14
Maintenance ...........................................
General..........................................................................15
Cleaning ........................................................................15
Remove Lime and Mineral Deposits..............................16
Draining Heater for Service Protection ..........................16
Resetting the Energy Cut-Off Switch (ECO)..................16
Troubleshooting Guide ...................................
Options and Accessories..................................
Limited Warranty........................................
Authorized Parts Distributors............................Bac
IMPORTANT OWNER INFORMATION
Record the model number, serial number (located on the lower
right side on the front of the unit), voltage and purchase date of
your Water Heater in the spaces below. Please have this
information available when calling Hatco for service assistance.
Model No. ____________________________________
Serial No. ____________________________________
Voltage ______________________________________
Date of Purchase ______________________________
Register your unit!
Completing online warranty registration will prevent delay in
obtaining warranty coverage. Access the Hatco website at
www.hatcocorp.com, select the Parts & Service pull-down
menu, and click on “Warranty Registration”.
Business 8:00 AM PMto 5:00
Hours: Central Standard Time (C.S.T.)
(Summer Hours: June to September –
8:00 AM PMto 5:00 C.S.T.
Monday through Thursday
8:00 AM PMto 2:30 C.S.T. Friday)
Telephone: (800) 558-0607; (414) 671-6350
E-mail: partsandservice@hatcocorp.com
Fax: (800) 690-2966 (Parts and Service)
(414) 671-3976 (International)
Additional information can be found by visiting our web site at
www.hatcocorp.com.
24 Hour 7 Day Parts and Service
Assistance available in the United States
and Canada by calling (800) 558-0607.
INTRODUCTION
Form No. 3CSFRM-0112
2
CONTENTS
Hatco FR and 3CS heaters are designed to supply temperature-
controlled water to a sink or holding vessel located above the
heater. Water flows by natural convection from the sink or
holding vessel into the heater directly downward into the rear
reservoir. The rear reservoir acts as a soil collection sump.
Debris that could affect the heating element operation settles
out in the sump to be drained away later. The debris free water
flows into the second reservoir in which the heating elements
are mounted. The water is heated and returns upward to the
sink or holding vessel.
All electrical and plumbing connections are factory-assembled
and ready for installation.
Hatco FR and 3CS Water Heaters are products of extensive
research and field testing. The materials used were selected for
maximum durability, attractive appearance and optimum
performance. Every unit is thoroughly inspected and tested prior
to shipment.
This manual provides the installation, safety, and operating
instructions for Hatco Water Heaters. Hatco recommends that
all installation, operating, and safety instructions appearing in
this manual be read prior to installation or operation of a unit.
Safety information that appears in this manual is identified by
the following signal word panels:
WARNING indicates a hazardous situation which, if not
avoided, could result in death or serious injury.
CAUTION indicates a hazardous situation which, if not
avoided, could result in minor or moderate injury.
NOTICE is used to address practices not related to
personal injury.
WARNING
CAUTION
NOTICE
Read the following important safety information before using this equipment to avoid serious injury or death and
to avoid damage to equipment or property.
ELECTRIC SHOCK HAZARD:
• Units supplied without an electrical cord and plug
require a hardwired connection to on-site electrical
system. Connection must be properly grounded and of
correct voltage, size, and configuration for electrical
specifications of unit. Contact a qualified electrician to
determine and install proper electrical connection.
• Units supplied with an electrical cord, plug, and
receptacle require installation of receptacle to on-site
electrical system. Connection must be properly
grounded and of correct voltage, size, and
configuration for electrical specifications of unit.
Contact a qualified electrician to determine and install
proper electrical connection.
• Unit must be installed by qualified, trained installers.
Installation must conform to all local electrical and
plumbing codes. Installation by unqualified personnel
will void the unit warranty and may lead to electric
shock or burn, as well as damage to unit and/or its
surroundings. Check with local plumbing and electrical
inspectors for proper procedures and codes.
• Unit is not weatherproof. Locate the unit indoors where
the ambient air temperature is a minimum of 70°F
(21°C).
• Turn OFF power switch, unplug power cord/turn off
power at circuit breaker, and allow unit to cool before
performing any cleaning, adjustments, or maintenance.
• DO NOT submerge or saturate with water. Unit is not
waterproof. Do not operate if unit has been submerged
or saturated with water.
• Do not clean unit when it is energized or hot.
• This unit is not “jet-proof” construction. Do not use jet-
clean spray to clean this unit.
• Discontinue use if power cord is frayed or worn.
• Do not attempt to repair or replace a damaged power
cord. Cord must be replaced by Hatco, an Authorized
Hatco Service Agent, or a person with similar
qualifications.
• This unit must be serviced by qualified personnel only.
Service by unqualified personnel may lead to electric
shock or burn.
• Use only Genuine Hatco Replacement Parts when
service is required. Failure to use Genuine Hatco
Replacement Parts will void all warranties and may
subject operators of the equipment to hazardous
electrical voltage, resulting in electrical shock or burn.
Genuine Hatco Replacement Parts are specified to
operate safely in the environments in which they are
used. Some aftermarket or generic replacement parts
do not have the characteristics that will allow them to
operate safely in Hatco equipment.
FIRE HAZARD:
• Install unit with a minimum of 3-1/2″ (89 mm) of space
from bottom of unit to all combustible surfaces to
prevent combustion.
• Do not use harsh chemicals such as bleach (or cleaners
containing bleach), oven cleaners, or flammable
cleaning solutions to clean this unit.
Make sure all operators have been instructed on the safe
and proper use of the unit.
This unit is not intended for use by children or persons
with reduced physical, sensory, or mental capabilities.
Ensure proper supervision of children and keep them away
from the unit.
Hatco Corporation is not responsible for actual food
product serving temperature. It is the responsibility of the
user to ensure that food product is held and served at a
safe temperature.
This unit has no “user-serviceable” parts. If service is
required on this unit, contact an Authorized Hatco Service
Agent or contact the Hatco Service Department at
800-558-0607 or 414-671-6350; fax 800-690-2966; or
International fax 414-671-3976.
BURN HAZARD:
• Some exterior surfaces on unit will get hot. Avoid
unnecessary contact with unit.
• Drain water may reach temperatures in excess of 200°F
(93°C). Use appropriate plumbing materials when
installing drain.
• Water in holding vessel may reach temperatures in
excess of 190ºF (88ºC). Use appropriate protection
when operating unit.
• Hot water in unit may cause scalding injury. Allow unit
to cool before draining or cleaning.
• Do NOT set temperature control higher than 190ºF
(88ºC). Units are designed to heat water up to 190ºF
(88ºC). Water over 190°F (88°C) is very active and could
splash onto operator causing serious burns or injury.
Do not use extension pipes on the inlet and outlet
connections on water heater units. Poor performance or
unsafe conditions may occur.
WARNING
CAUTION
3
Form No. 3CSFRM-0112
IMPORTANT SAFETY INFORMATION

Specyfikacje produktu

Marka: Hatco
Kategoria: Podgrzewacz
Model: 3CS-6-208-3-QS

Potrzebujesz pomocy?

Jeśli potrzebujesz pomocy z Hatco 3CS-6-208-3-QS, zadaj pytanie poniżej, a inni użytkownicy Ci odpowiedzą


Instrukcje Podgrzewacz Hatco

Hatco

Hatco S-40 Instrukcja

22 Września 2024
Hatco

Hatco 3CS2-3 Instrukcja

22 Września 2024
Hatco

Hatco 3CS-6B Instrukcja

21 Września 2024
Hatco

Hatco FR-9B Instrukcja

21 Września 2024
Hatco

Hatco 3CS-3B Instrukcja

21 Września 2024
Hatco

Hatco 3CS2-4 Instrukcja

21 Września 2024
Hatco

Hatco 3CS2-3B Instrukcja

21 Września 2024
Hatco

Hatco FR2-4B Instrukcja

21 Września 2024
Hatco

Hatco FR2-4 Instrukcja

21 Września 2024
Hatco

Hatco 3CS-4 Instrukcja

21 Września 2024

Instrukcje Podgrzewacz

Najnowsze instrukcje dla Podgrzewacz

Harvia

Harvia Delta D29EE HDEE290400 Instrukcja

15 Października 2024
Jotul

Jotul F 361 Instrukcja

15 Października 2024
Adler

Adler AD 7752 Instrukcja

15 Października 2024
MSW

MSW -TTEH-3000 Instrukcja

15 Października 2024
MSW

MSW IR-DRYER2000.2 Instrukcja

15 Października 2024
MSW

MSW IR-DRYER3000.1 Instrukcja

15 Października 2024
MSW

MSW IR-DRYER2000.1 Instrukcja

15 Października 2024
MSW

MSW IR-DRYER3000.2 Instrukcja

15 Października 2024
MSW

MSW -CHEH-3300 Instrukcja

15 Października 2024
MSW

MSW -CTEH-15000 Instrukcja

15 Października 2024