Instrukcja obsługi Buderus Logamax plus GB142-45
Buderus
kocioł centralnego ogrzewania
Logamax plus GB142-45
Przeczytaj poniżej 📖 instrukcję obsługi w języku polskim dla Buderus Logamax plus GB142-45 (100 stron) w kategorii kocioł centralnego ogrzewania. Ta instrukcja była pomocna dla 3 osób i została oceniona przez 2 użytkowników na średnio 4.5 gwiazdek
Strona 1/100
Please read thoroughly before installing and servicing
7212 9700 – 12/2004 US/CA(EN) For registered installers
Installation and Servicing instructions
Condensing gas heater
Logamax plus GB142-24/30/45/60
CAUTION!
Before putting the appliance into operation read this manual carefully.
WARNING!
Improper installation, adjustment, alteration, service or maintenance
can cause injury, loss of life or property damage. Refer to this manual.
For assistance or additional information consult a qualified installer,
service agency or the gas supplier.
CAUTION!
The operating manual is part of the documentation that is delivered to
the installation's operator. Go through the information in this manual
with the owner/operator and make sure that he or she is familiar with
all the necessary operating instructions.
Notice:
This manual must be retained for future reference.
–Do not store or use gasoline or other flammable vapors and
liquids in the vicinity of this or any other appliance.
– What to do if you smell gas
•Do not try to light any appliance
•Do not touch any electrical switch; do not use any phone in
your building.
•Immediately call your gas supplier from a neighbor’s phone.
Follow the gas supplier’s instructions.
•If you cannot reach your gas supplier, call the fire department.
– Installation and service must be performed by a qualified
installer, service agency or the gas supplier.
Warning: If the information in these instructions is
not followed exactly, a fire or explosion may result
causing property damage, personal injury or death.
2
We reserve the right to make any changes due to technical modifications!
Installation and Servicing instructions Logamax plus GB142-24/30/45/60 • Version 12/2004
Buderus Hydronic Systems • http://www.buderus.net
Preface
About these instructions
These Installation and Servicing Instructions contain
important information for the safe and professional
installation, start-up and maintenance of the appliance
with appliance capacities 24, 30, 45 and 60 kW.
These Installation and Servicing Instructions are
intended for specialist installers, who have the neces-
sary training and experience for working on heating and
gas systems.
Subject to technical changes!
Slight changes may be made to the illustrations, process
steps and technical data as a result of our policy of
continuous improvement.
Updating of documentation
Please contact us if you have any suggestions for
improvements or corrections.
Contents
3
We reserve the right to make any changes due to technical modifications!
Installation and Servicing Instructions Logamax plus GB142-24/30/45/60 • Version 12/2004
Buderus Hydronic Systems • http://www.buderus.net
1 Safety and general instructions . . . . . . . . . . 5
1.1 Designated use . . . . . . . . . . . . . . . . . . . . . . . . 5
1.2 Hazard definitions . . . . . . . . . . . . . . . . . . . . . . 5
1.3 The following instructions must be observed . . 5
1.4 Observe these instructions for heating
system water . . . . . . . . . . . . . . . . . . . . . . . . . . 6
1.5 Tools, materials and additional equipment . . . 6
1.6 Disposal . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
2 Regulations and guidelines . . . . . . . . . . . . . 7
3 Product description . . . . . . . . . . . . . . . . . . . . 8
4 Dimensions and connections . . . . . . . . . . . . 9
5 Packaging and transportation . . . . . . . . . . 11
5.1 Scope of delivery . . . . . . . . . . . . . . . . . . . . . . 11
5.2 Transporting the appliance . . . . . . . . . . . . . . 11
6 Installation . . . . . . . . . . . . . . . . . . . . . . . . . . 12
6.1 Requirements for the installation room . . . . . 12
6.2 Fitting the appliance. . . . . . . . . . . . . . . . . . . . 12
6.3 Making the gas connection . . . . . . . . . . . . . . 13
6.4 Fitting the heating circuit supply and
return pipes . . . . . . . . . . . . . . . . . . . . . . . . . . 14
6.5 Combustion Air and Ventilation Openings . . . 17
6.6 Installation of the flue gas adapter
(included in the scope of delivery) . . . . . . . . . 18
6.7 Installation of the Exhaust and
Air Intake system. . . . . . . . . . . . . . . . . . . . . . 18
7 Connecting the condensate water drain . . 23
8 Electrical connections. . . . . . . . . . . . . . . . . 24
8.1 External connection board connections . . . . .24
9 Start-up procedure. . . . . . . . . . . . . . . . . . . . 27
9.1 Testing for gas leaks . . . . . . . . . . . . . . . . . . . 28
9.2 Filling the appliance . . . . . . . . . . . . . . . . . . . . 28
9.3 Filling the condensate trap. . . . . . . . . . . . . . . 29
9.4 Venting the gas supply valve . . . . . . . . . . . . . 29
9.5 Checking the combustion air/flue gas
connection . . . . . . . . . . . . . . . . . . . . . . . . . . . 30
9.6 Checking the orrifices . . . . . . . . . . . . . . . . . . 30
9.7 Inlet gas pressure . . . . . . . . . . . . . . . . . . . . . 30
9.8 Checking and adjusting the gas/air ratio . . . . 31
9.9 Carrying out a tightness test in operating
conditions. . . . . . . . . . . . . . . . . . . . . . . . . . . . 33
9.10 Measuring the carbon monoxide
content (CO) . . . . . . . . . . . . . . . . . . . . . . . . . 33
9.11 Function testing . . . . . . . . . . . . . . . . . . . . . . . 33
9.12 Measuring the ionization current . . . . . . . . . . 33
9.13 Installing the casing . . . . . . . . . . . . . . . . . . . . 35
9.14 Informing the owner, handing over the
technical documents . . . . . . . . . . . . . . . . . . . 35
10 BC10 basic controller . . . . . . . . . . . . . . . . . 36
10.1 Operating the BC10 basic controller . . . . . . . 36
10.1.1 Switching the heating system on and off . . . . 36
10.1.2 Displaying the operating conditions of
the burner and resetting the burner or
resetting burner faults . . . . . . . . . . . . . . . . . . 36
10.1.3 Displaying the heating system status
and/or faults. . . . . . . . . . . . . . . . . . . . . . . . . . 37
10.2 Carrying out additional tasks . . . . . . . . . . . . . 39
10.2.1 Carrying out a flue gas test . . . . . . . . . . . . . . 39
10.2.2 Selecting partial load operation
(e. g. during flue gas testing). . . . . . . . . . . . . 39
10.2.3 Switching the heating system to
manual mode. . . . . . . . . . . . . . . . . . . . . . . . . 39
10.3 Configuring the appliance . . . . . . . . . . . . . . . 40
10.3.1 Adjusting the heating capacity. . . . . . . . . . . . 40
10.3.2 Setting the DHW temperature value . . . . . . . 41
10.3.3 Entering the heater water temperature . . . . . 41
10.3.4 Setting the pump post-purge period . . . . . . . 41
11 Shutting down the system . . . . . . . . . . . . . 43
11.1 Shut down the heating system using
the control unit . . . . . . . . . . . . . . . . . . . . . . . . 43
11.2 Shutting down the heating system
in the event of an emergency . . . . . . . . . . . . 43
12 Inspection . . . . . . . . . . . . . . . . . . . . . . . . . . 44
12.1 Preparing the appliance for inspection . . . . . 44
12.2 Visual inspection for general signs of
corrosion . . . . . . . . . . . . . . . . . . . . . . . . . . . . 44
12.3 Internal tightness testing . . . . . . . . . . . . . . . . 45
12.4 Measuring the ionization current . . . . . . . . . . 45
12.5 Measuring the inlet gas pressure . . . . . . . . . 45
12.6 Checking and adjusting the gas/air ratio . . . . 45
12.7 Carrying out a gas tightness test in
operating conditions . . . . . . . . . . . . . . . . . . . 45
12.8 Measuring the carbon monoxide
content (CO) . . . . . . . . . . . . . . . . . . . . . . . . . 45
12.9 Carrying out a pressure test of the
heating system . . . . . . . . . . . . . . . . . . . . . . . 45
12.10 Checking the functioning and the safety
of the air intake and flue gas conduit. . . . . . . 45
12.11 Checking venting systems. . . . . . . . . . . . . . . 45
13 Maintenance. . . . . . . . . . . . . . . . . . . . . . . . . 46
13.1 Cleaning the heat exchanger, burner
and condensate trap . . . . . . . . . . . . . . . . . . . 46
13.2 Checking and adjusting the gas/air-ratio . . . . 48
14 Servicing . . . . . . . . . . . . . . . . . . . . . . . . . . . 49
14.1 Checking the UBA3 fuse;
replace if necessary . . . . . . . . . . . . . . . . . . . 49
14.2 External connection board fuse . . . . . . . . . . . 49
14.3 Checking the fan unit; 120 VAC control . . . . 50
14.4 Checking the fan unit;
Supply cord (120 VAC) . . . . . . . . . . . . . . . . . 51
14.5 Checking the fan unit; Tacho cable . . . . . . . . 52
14.6 Replacing the fan unit . . . . . . . . . . . . . . . . . . 52
14.7 Checking the supply/return/safety/
hot-water temperature sensors . . . . . . . . . . . 53
14.8 Replacing the supply/return/safety sensors . 54
14.9 Checking the supply/return/
safety sensors cable . . . . . . . . . . . . . . . . . . . 55
14.10 Checking the hot surface ignitor; Control . . . 56
14.11 Checking the hot surface ignitor; resistance . 57
Specyfikacje produktu
| Marka: | Buderus |
| Kategoria: | kocioł centralnego ogrzewania |
| Model: | Logamax plus GB142-45 |
Potrzebujesz pomocy?
Jeśli potrzebujesz pomocy z Buderus Logamax plus GB142-45, zadaj pytanie poniżej, a inni użytkownicy Ci odpowiedzą
Instrukcje kocioł centralnego ogrzewania Buderus
13 Stycznia 2025
10 Października 2024
6 Października 2024
4 Października 2024
3 Października 2024
28 Września 2024
26 Września 2024
16 Września 2024
16 Września 2024
12 Września 2024
Instrukcje kocioł centralnego ogrzewania
- kocioł centralnego ogrzewania Morco
- kocioł centralnego ogrzewania Bosch
- kocioł centralnego ogrzewania Ferroli
- kocioł centralnego ogrzewania Remeha
- kocioł centralnego ogrzewania Truma
- kocioł centralnego ogrzewania Ariston Thermo
- kocioł centralnego ogrzewania Intergas
- kocioł centralnego ogrzewania Kospel
- kocioł centralnego ogrzewania Viessmann
- kocioł centralnego ogrzewania Vaillant
- kocioł centralnego ogrzewania Baxi
- kocioł centralnego ogrzewania Worcester
- kocioł centralnego ogrzewania Atag
- kocioł centralnego ogrzewania Junkers
- kocioł centralnego ogrzewania ACV
- kocioł centralnego ogrzewania De Dietrich
- kocioł centralnego ogrzewania Nefit
- kocioł centralnego ogrzewania A.O. Smith
- kocioł centralnego ogrzewania AGPO
- kocioł centralnego ogrzewania Itho
- kocioł centralnego ogrzewania Stiebel Eltron
- kocioł centralnego ogrzewania Elco
- kocioł centralnego ogrzewania Masterwatt
- kocioł centralnego ogrzewania Nibe
- kocioł centralnego ogrzewania Itho-Daalderop
- kocioł centralnego ogrzewania Saunier Duval
- kocioł centralnego ogrzewania Vokèra
- kocioł centralnego ogrzewania Bulex
- kocioł centralnego ogrzewania AWB
- kocioł centralnego ogrzewania Fantini Cosmi
- kocioł centralnego ogrzewania Wolf
- kocioł centralnego ogrzewania La Nordica
- kocioł centralnego ogrzewania Daalderop
- kocioł centralnego ogrzewania Tzerra
- kocioł centralnego ogrzewania Weishaupt
- kocioł centralnego ogrzewania Mikoterm
- kocioł centralnego ogrzewania Brink
- kocioł centralnego ogrzewania Oertli
- kocioł centralnego ogrzewania Ygnis
- kocioł centralnego ogrzewania ROC
- kocioł centralnego ogrzewania Thermona
Najnowsze instrukcje dla kocioł centralnego ogrzewania
15 Stycznia 2025
13 Stycznia 2025
13 Stycznia 2025
13 Stycznia 2025
13 Stycznia 2025
11 Stycznia 2025
28 Grudnia 2024
28 Grudnia 2024
27 Grudnia 2024
15 Października 2024